电子生产术语中英文对照表生产术语中英文对照表PRODUCTION FLOOR TECHNICAL TERMINOLOGY TRAINIG中文名称英文名称中文名称英文名称部门：SMT&REFLOW-SOLDERING箱子Bins锡膏Solderpaste IC脚共面coplanarity锡膏印刷机Solderpasteprinter 激光传感器Laser sensor钢网Stencil 监视器Monitor冰箱Refridgerator 印刷板Printedcircuitboard(PCB)手工印刷Manualprinting 印刷板Printedwiringboard(PWB)自动印刷Automatic 印制板PCBprinting 装配assembly(PCBA)钢网清洁Stencil-cleaning 印制板装配Printedwiringassembly加锡膏Solderpastetop-up 氮气回流炉N2 reflow刮刀Squeegee 水准测试leveling刮刀压力Squeegeepressure 锡膏搅拌器Solder pastemixer刮刀角度Squeegeeangle 线形贴片机Linearmounter刮刀Spatula 旋转形贴片机Turret-typemounter罐子Jar 热电偶Thermocouple管子Tube 锡膏厚度测量Solder paste heightmeasurement红胶水Epoxyadhensive贴装过程Pick&place晶体贴片机Clipmounter IC贴片机ICmounter 回焊前Pre-reflow 回焊后Post-reflow回流炉Reflowoven回流焊接Reflowsoldering表面贴装元件Surface mount devices湿度敏感元件Moisture-s ensitive devices隔离机器发现的不良元件Machine throw-out机器丢料Machinedrop-out炉温曲线Profile炉温测量仪Profiler控制图Controlcharts生产记录Output/yield records手提插箱Magazine托盘Tray架子Racks手推车trolleys中文名称英文名称中文名称英文名称部门：MANUALINSERT&WA VE-SOLDERING手插件Manualinsertion 生产线清空Line purge插件Pin-through-hole箱Bins镀通孔Plated-through-hole 比重Specificgravity(density)插件Put-through-hole焊烟Fumes用水清洗的系统Cleansystem硬化Curing免水清洁的系统No-cleansystem工效学Ergonomics松香Flux 插件顺序Sequence of insertion主波Lambdawave过炉前Pre-wave纵横波Turbulencewave过炉后Post-wave松香喷雾器Spray-fluxer控制屏Control panel 松香槽Flux-bath 显微镜Microscope 锡条Solder bar 放大镜Magnificationlamp锡炉Solder-pot 放大镜visionscope炉参数Ovenparameters爪子Fingers链条Conveyor 接触面Area ofcontact水平器/玻Glass plae 璃片排气Exhaust预热Pre-heating融锡Moltensolder平行Parallelism 周期Cycle time 冷却硬化Oven-curing执锡Touch-up 毛细管现象Capillaryaction卡板Pallet电烙铁Soldering-iron烙铁头Iron tip 海绵Sponge烙铁温度检查Iron temperatu re checker转换conversion中文名称英文名称中文名称英文名称部门：PCB焊盘Pad 公共线路Common trace焊盘Land 装备孔Mountingholes阻焊剂Solder-thief通孔viahole阻焊剂Solderresist UL 标识UL logo线路Trace 日期编码Datecode 回路Circuit 绿油Masking固定孔Mountingholes 镀通孔Plated-through hole测试点Test-points 面板Panel散热器Heat sink 分板路线Singulation/ro uting电路板/控制阻抗Controlledimpedance镀金线路板Gold-platedPCB分层Delamination 防潮PCBEntek PCB短路/连锡Bridging 喷锡板Hot-air solder leveling(HASL) PCB 短路Short开路Open线路开路Brokentrace破裂Cracked翘起Warped弯曲Bow位置丝印Locationprinting丝印Silk-screenprinting阻焊剂/ Mask脏/污物contamination部门：MANUAL-ASSEMBLY&MANUAL-SOLDERING电批Torquedriver毛刺Burr/flashing 螺丝Screws 生锈Rusty螺母Nuts 失去光泽Tarnished支架Brackets 腐蚀的Corroded金属部件Metalparts 凹痕，缺口Dented塑胶部件Plasticparts弯曲的Bent容器/集装箱Containers 镀金属的Plated贴纸Stickers 磨光的polished 自带胶贴纸Self-adhensive labels水口High gate印油Markemink 少胶Short-moulded盖印Stamping 水纹Flowline 标识Marking 防潮剂Conformalcoating锡线Solderwire 条码标签Barcode label松香笔Flux pen 日期盖印Datecode stamping镊子tweezer风批Pneumatic/screwdriver中文名称英文名称中文名称英文名称部门：TESTING线路测试仪In-circuittester 未经测试元件清单Untestedcomponentlist功能测试仪Functionaltester 局部测试元件Partially-tested component清单list测试针Toggle pins 固件Firmware真空Vaccum 烧录IC IC-programm ing实验建立/测试调试Hotmock-up(HMU)邦定Bonding电线Cable 晶体Die测试软件Testsoftware 铝线Alumimiumwire测试软件版本Testsoftwareversion金线Gold wire调试Debug 封胶Encapsulation修理Repair 混合胶2-componentadhensive模拟Simulation 注射器Syringe首次合格量First-passyield 拉力测试Pull-test最终合格量Final passyield 破坏性测试Destructivetest部门：PACKING卡板/货盘Pallet 纸箱/卡通箱Carton卡纸/分隔纸板Cardboard separators泡泡袋Bubble-pack防静电袋ESD-shielding bag透明胶纸Opp tape 电脑条形码Barcode 包装带/皮带材料Strapping卷带Cling-wrap热缩带/用收缩性薄膜包装Shrink-wr ap托盘Tray泡沫foam真空包装Vacuum-pack。