导热油锅炉价格—导热油锅炉官方价格简介：导热油锅炉详细说明：导热油锅炉，导热油锅炉价格，导热油锅炉厂家，导热油锅炉批发YLW系列导热油炉是以煤炭、轻油、重油为燃料，以导热油为热载体，利用热油循环泵强制液相循环，将热能输送给用热设备，继后返回热油炉重新加热的直流式特种工业炉。
导热油锅炉一般分为燃油导热油锅炉，燃气导热油锅炉，燃煤导热油锅炉。
燃煤导热油锅炉是以煤为燃料，导热油为热载体。
利用循环油泵强制液相循环，将热能输送给用热设备后，继而返回重新加热的直流式特种工业炉。
一般分为立式手烧、卧式圆筒型、卧式机烧三种燃煤结构形式，主要是根据加煤的劳动强度从而分了这三种形式。
燃油（气）导热油锅炉是以燃油或燃气为燃料，利用燃烧器燃燃料，以导热油为热载体。
利用循环油泵强制液相循环，将热能输送给用热设备后，继而返回重新加热的直流式特种工业炉。
一般分为立式、卧式二种结构形式，主要是根据设备空间高度这二种形式。
导热油锅炉使用注意事项1.使用斯大导热油作为热载体的油、气的热载体锅炉，系统应配备膨胀槽，储油罐、安全组件，测量仪表和控制装置。
2.导热油投入使用时，在开始运行阶段，先启动循环油泵，运行半小时后，再点火升温，初次使用时应缓慢升温，每小时升温约20 ℃，当升温至180~200℃时，再保温一段时间，方可投入正常使用。
3.在使用中应认真检查，严防水、酸、碱及低沸点物漏入使用系统，系统应装过滤装置，防止各种杂物进入，保证油品纯度。
4.经使用半年后，应进行一次油品分析，长期使用后，若发现传热效果差，或其它异常情况，应对油品进行分析，根据分析结果决定添加或更换，判断标准量：碱碳不大于1.0%，酸值不大于0.5mgK(OH)/g,燃点变化不小于20%，粘度变化不大于10%，其中一项超标应更换新油。
5.为确保导热油的正常使用寿命和导热效果，严禁超温使用。
其成份为：氢氧化钠（烧碱），每吨炉水加8-10kg，如果选用碳酸钠（纯碱），则每吨炉水加20kg，或磷酸二钠，每吨炉水加20kg。
待碱性溶液全部加入后，再用软水注入锅炉，直至水从锅炉最高处冒出为止，关闭给水阀后，注意使锅炉内碱性溶液混合均匀。
保养期内要定期微火烘炉、定期使水循环，使各处碱性溶液浓度一致。
每五天还要取碱性溶液化验，如碱度小于5-12mmol/1时应外加溶液。
气候寒冷的地方不可采用湿保养法，以免炉水结冻损坏锅炉。
河北艺能导热油锅炉价格信息。
品牌:宇星机械，型号:20万大卡，燃烧方式:室燃炉，循环方式:自然循环锅炉，出口压力:中压，锅炉用途:工业锅炉，适用燃料:柴废料，结构形式:立式。
河北艺能导热油锅炉价格35000元/台。
公司地址：河北省沧州市吴桥县开发区东首邮编：061800本厂生产20万-160万大卡导热油锅炉公司主要产品有：导热油炉、导热油锅炉公司生产的设备主要适用于：宾馆、酒店、工厂、工地……本公司宗旨：以质量求生存，以信誉求发展，客户第一，用户至上，诚信为本，技术为先导热油锅炉价格：价格35000元/台燃油锅炉品牌：艺能产品说明：YYL(YYW)系列有机热载体炉为快装式强制循环燃油（气）锅炉。
本系列锅炉本体受热面结构紧凑，受热面由内、中、外（或内、外）密排的圆盘管构成；内盘管为辐射受热面，中、外盘管与内盘管的外表面构成对流受热面。
燃料在内盘管组成的燃烧室内燃烧放热，经辐射受热面吸收大部分热量后，高温烟气进入对流受热面进行换热，出锅炉后在空气预热器中加热锅炉燃烧所需的空气，再经除尘器由引风机将烟气送至烟囱排入大气安装极其方便灵活，只要将锅炉就位于其基础上即可。
受热面采用密排圆盘管，受热面布置充足，降低管子表面热负荷，是导热油使用更安全。
炉膛尺寸与燃烧火焰相匹配，采用了正压燃烧，辐射换热效率高。
锅炉结构紧凑，大大节约了锅炉房的占地面积。
大型锅炉尾部设置空气预热器，提高锅炉效率。
工作温度：0～350℃工作介质：导热油工作压力：常压设计压力：1MPa供热能力：500～12000kW（40～1000万大卡／时）产品规格：单台供热能力为40、60、80、100、120、150、200、300、400、500、600、700、800、900、1000万大卡／时燃烧方式：链条燃煤炉排、往复炉排,电、燃油、燃气适用燃料：电、燃油、燃气、煤、木材、树皮、边板废料、砂光粉自动控制：机械化、自动控制燃烧方式、变频控制、比例调节、PLC 可编程及触摸屏控制技术。
导热油锅炉的保养：1、锅炉本体受热面长期不用的保养方法：有干法和湿法两种。
停炉一个月以上，应采用干保养法，停炉一个月心以下可采用湿保养法。
干保养法：锅炉停炉后放去锅水，将内部污垢彻底清除，冲洗干净。
在炉膛内用微火烘干（注意不要用大火），然后将10-30毫米块状的生石灰分盘装好，放置在锅筒内，不使生石灰与金属接触，生石灰的重量，以锅筒容积每立方米8kg计算，然后将所有的人孔、手孔、管道阀门关闭，每三个月检查一次，如生石灰碎成粉状，须即更换，锅炉重新运行时应将生石灰和盘取出。
湿保养法：锅炉停炉后待炉水冷却到70℃以下将炉水放尽，将内部污垢彻底清除，冲洗干净，所有的人孔、手孔、管道阀门等封闭严密，并用盲板与运行中的锅炉完全隔绝。
然后重新注入已处理的软水至锅炉最低安全水位，再将以配制好的碱性溶液注入锅炉。
标签：导热油锅炉河北艺能锅炉有限责任公司（原吴桥县导热油锅炉有限责任公司）坐落于天下闻名的杂技之乡—吴桥，年产导热油锅炉壹千伍佰余台套，已成为国内北方规模最大的有机热载体加热炉研发制造基地。
关键字：导热油锅炉Heat conducting oil boiler priceIntroduction: heat-conducting oil boilerDetailed description: conducting oil boiler, heat-conducting oil boiler,heat-conducting oil boiler manufacturers, heat-conducting oil boiler wholesale YLW series thermal oil furnace with coal, light oil, heavy oil as fuel, with thermal conductive oil as heat carrier, using hot oil circulation pump forced liquid circulation, the heat transfer to the heat equipment, then return to hot oil furnace heating type special industrial furnace.Heat conducting oil boiler is generally divided into fuel oil boiler, gas heat conducting oil boiler, coal-fired thermal oil boiler.Coal fired heat conducting oil boiler using coal as fuel, heat conductive oil as heat carrier.Using liquid-phase circulation pump forced circulation, the heat transfer to the use of thermal equipment, then return to the DC special industrial furnace heating.Generally divided into vertical hand burn, horizontal cylinder type, horizontal type machine burning three kinds of coal structure, are based mainly on coal labor strength thus divided the three forms.Fuel oil ( gas ) heat conducting oil boiler in oil or gas as fuel, the burner of fuel, with thermal conductive oil as heat carrier.Using liquid-phase circulation pump forced circulation, the heat transfer to the use of thermal equipment, then return to the DC special industrial furnace heating. Generally divided into vertical, horizontal two structural forms, are based mainly on the equipment space height of these two forms.Heat conducting oil boiler use matters needing attentionThe 1 was used in heat conductive oil as heat carrier oil, gas heat carrier boiler, the system should be equipped with expansion tank, oil storage tank, safety components, instrumentation and control device.2 heat conduction oil into use, running at the beginning stage, first start the circulation pump, running after half an hour, and then the ignition temperature, initial use should slow heating, warming of about 20 degrees per hour, when warming up to 180~200 ℃, longer holding time, may be put into normal use.3 in use should be carefully checked, take strict precautions against water, acid, alkali and low boiling point substance leakage into the use of system, system should be installed filtering device, to prevent all kinds of debris into the, ensure oil purity.By 4 after half a year, should be performed once oil analysis, after long-term use, if it is found that the heat transfer effect is poor, or other abnormal situations, dealing with oil are analyzed, according to the analysis results the decision to add or replace, judgment standard weight: carbon base of not more than 1%, acid value is less than 0.5mgK ( OH ) /g light changes, not less than in 20%, the viscosity changes of not more than 10%, one of them exceed the standard should be replaced with new oil.5 in order to ensure the normal service life of heat conduction oil and thermal effect, prohibited the use of temperature.The ingredients are: sodium hydroxide ( caustic soda ), per ton of water plus8-10kg, if the choice of sodium carbonate (sodium carbonate ), then the unit boiler water plus 20kg, or phosphoric acid two sodium, per ton of water plus20kg.The alkaline solution after all to join, with soft water into the boiler, water from the boiler to the highest out of date, the feed water valve is closed, the alkaline solution is uniformly mixed in the boiler. The maintenance period to ensure regular oven, regularly make water circulation, can make each alkaline solution concentration of the same.Every five days to take the alkaline solution assays, such as the alkalinity of less than 5-12mmol/1 should be applied solution.The cold can not use wet maintenance method, so as to avoid freezing damage of boiler water boiler.Hebei arts conducting oil boiler price information. Brand: Star Machinery, models: 200000 calories, combustion chamber combustion furnace, circulation way:: natural circulation boiler: boiler pressure, outlet pressure, use: industrial boiler, fuel available: wood waste, structural forms: vertical. Hebei arts conducting oil boiler price 35000 yuan / taiwan.Company address: Hebei province Cangzhou city Wuqiao County Development Zone East firstZip code: 061800The factory produced 200000 -160 million kcal heat-conducting oil boilerThe company's main products are: conducting oil furnace, heat conducting oil boilerThe company production equipment is mainly applicable to: hotels, hotel, factory, the site ... ...The company aims: to the quality of survival, to the credibility of development, customer first, the user is supreme, integrity-based, technology firstHeat conducting oil boiler price : the price of 35000 yuan / TaiwanFuel oil boiler brand : ArtProduct description:YYL ( YYW ) series of organic heat carrier furnace for quick assembly type forced circulation of fuel ( gas ) boiler.This series of boiler heating surface has the advantages of compact structure, heating surface from the inside, outside, in ( or, ) a close-packed circular pipe; inner tube for radiation heating surface, in the outer tube and inner tube, the outer surface of a convection heating surface.Fuel in the inner tube is composed of combustion heat release, the radiation heating surface absorb most of heat, high temperature flue gas enters the convection heating surface of heat exchanger, the boiler air preheater of boiler in heating the air required for combustion, and then by the dust remover comprises a draught fan will be sent to the chimney flue gas discharged into the atmosphereConvenient installation and flexible, as long as the boiler on the base of the can.Heating surface the closely-aligned round pipe, heating surface arrangement is sufficient, reduce the surface heat load of pipe, heat transfer oil use more safety.Furnace size matches the combustion flame, using positive pressure combustion, radiation heat transfer efficiency.The boiler has the advantages of compact structure, greatly saves the space of boiler room.Large boiler installed at the end of the air preheater, to improve the efficiency of boiler.Operating temperature: 0℃to 350 ℃Working medium: conducting oilWorking pressure : pressureDesign pressure: 1MPaHeating capacity: 500～12000kW ( 40 ～10000000 kcal / hour )Product specification: single heat supply capacity is 40, 60, 80, 100, 120, 150, 200, 300, 400, 500, 600, 700, 800, 900, 10000000 kcal / hourCombustion mode: coal-fired grate, grate, electricity, fuel, gasApplication fuel: electric, fuel, gas, coal, wood, bark, side plate waste, sand powderAutomatic control: mechanical, automatic combustion control, frequency control, proportional control, programmable PLC and touch screen control technology.Heat conducting oil boiler maintenance:In 1, the boiler heating surface without long-term maintenance method: dry and wet two. Shutdown for more than a month, should be used to do maintenance, stop for a month following the maintenance method of wet heart.Dry maintenance of law: after the shutdown of the boiler to put the pot of water, the interior completely remove the dirt, rinse clean.In the hearth with Weihuo drying ( do not pay attention to fire ), then 10-30 mm lump lime disk installed, placed in a boiler barrel, do not make contact with the metal with lime, lime weight, to drum volume per cubic meter of 8kg calculation, and then all the manhole, hand hole, pipeline valves off, checked every three months, such as lime crushed into powder, should be replaced, the boiler to run when the lime and disc removed.Wet maintenance of law: after the shutdown of the boiler for water cooling to below 70 ℃water discharge will, be completely remove the dirt, rinse clean, all of the manhole, hand hole, pipe valve closed tight, and the blind plate and the operation of the boiler is completely isolated. Then reinjected into the processed water to the boiler safe minimum level, and then to prepare alkaline solution into the boiler.Tags: heat-conducting oil boilerHebei arts boiler limited liability company ( the original Wuqiao Countyheat-conducting oil boiler limited liability company ) is located in the world famous acrobatic village - Wuqiao, with an annual output of heat conducting oil boiler Yiqianwubaiyu sets, has become the North's largest organic heat carrier heating furnace for R & D and manufacturing base.Keywords: heat-conducting oil boiler。