操作说明书operating instruction标准操作程序standard operating procedure开车start-up试车running-in在操作中（在运转中）on stream装载load up装罐（产品）run-down停车shut-down预防修理（小修）turn-around正常停车normal shutdown运转周期run length冲洗flushing喷射清洗jet cleaning化学清洗chemical cleaning大修overhaul盘车barring研磨lapping干燥dry out电干燥electric drying运转中检查（在线检查）on-stream inspection 在线维修on-stream maintenance生产保全productive maintenance间歇操作batch operation半间歇操作semi-batch operation连续操作continuous operation制备preparation补充make-up回收recovery再生regeneration循环recycle再循环recycle除焦decoking放空vent蒸汽吹扫steaming out吹扫purge抽真空evacuation吹出blow-off排污blowdown息火blow-out事故排放emergency vent安全放空conservation vent阻火器flame arrester防爆膜（爆破片）rupture disc安全泄气阀safety valve事故切断阀emergency valve过流防止阀excess flow valve排放阀discharge valve破真空vacuum breaker大气腿barometric leg锁开locked open锁关locked close铅封开（未经允许不得关闭）car sealed open 旁路by-pass操作管线on-stream line备用stand-by15.2 操作状态污染containation波动fluctuation操作稳定性operating stability溢流、液泛flooding沟流channeling停留时间(1) residence time(2) retention time滞留量hold up界面interface飞沫priming物沫夹带entrainment漏液weeping发泡foaming回火back-fire净正吸入压头NPSH回流reflux转化率conversion进料feed输入intake冷凝液condensate放净drain塔顶流出物overhead釜液bottoms饱和蒸汽saturated steam过热蒸汽superheated steam直接蒸汽live steam窒息蒸汽smothering steam鼻烟蒸汽snuffing steam雾化蒸汽atomizing steam16. 防火和环保16.1 消防设备水龙带fire hose水管接口water nozzle消防栓hydrant供水口siamese connection泡沫灭火剂foam空气泡沫发生器air foam chamber上升管过滤器riser strainer消防软管接口fire hose connection泡沫接口foam nozzle水枪monitor喷头head喷头、喷嘴spray水喷淋（罐顶）deluge水喷淋（罐壁）drencher洒水器sprinkler雾化fog水喷淋wateringCO2 灭火系统CO2extinguishing system灭火器fire extinguisher干粉灭火器dry chemical powder消防水泵fire pump稳压泵jockey pump消防车fire fighting trunk急救车、救护车ambulance car16.2 火灾报警设备自动火灾报警系统automatic fire alarm system 监视器detector发送器、变送器transmitter接收器receiver转送器(1) translater(2) repeater火灾监视区fire watching zone火灾检测区fire sensing zone漏电报警器leak alarm device16.3 其它防火设备阻火器flame arrester紧急切断阀emergency isolation valve安全（泄气）阀safety valve爆破片（膜）rupture disc联锁interlock防护堤dike防爆墙explosion proofing wall避雷器lightning arrester避难指示灯emergency directional light避难路标emergency directional indication航空标识灯(1) aircraft warning light(2) aircraft obstruction light静电保护protection of static electricity线桥bonding地耳earth lug气体检测器gas detector噪音累积器noise exposure meter16.4 电气防爆防爆结构explosion-protected construction增安型increased safety type隔爆型flameproof type本质安全型(1) intrinsically safe type(2) intrinsic safety type正压通风型pressurized type浸油型oil-immersed type特殊型special type允许温升时间permissible locked-rotor time本安回路intrisically safe circuit本安连接回路associated circuit of intrinsically safe system非本安回路non-intrinsically-safe circuit本安电器设备intrincally safe appratus安全栅barrier正压通风室pressurized room密封sealing防爆容器enclosure vessel16.5 危险场所、火灾、爆炸危险区(1) hazardous area(2) hazardous location爆炸气体环境危险区hazardous areas for explosive gas at6mosphere 粉尘危险区hazardous area for dust爆炸气体explosive gas粉尘dust危险源source of hazard爆炸等级explosion class引燃温度组别ignition group引燃点(1) ignition point(2) fire point闪点flash point爆炸极限(1) limit of explosion(2) explosive limits蒸汽密度vapor density点火源ignition source静电static electrification爆炸explosion气体爆炸gas explosion粉尘爆炸dust explosion蒸汽爆炸vapor explosion最小点火能minimum ignition energy自燃spontaneous ignition燃烧热heat of combustion燃烧波combustion wave火球fire ball一次灾害primary disaster二次灾害secondary disaster16.6 化学设备、危险物、有害物允许浓度acceptable concentrations缺氧want of oxygen听力下降hearing loss16.7 安全安全工程safety engineering人类工程学human engineering人机系统man-machine system定期维修preventive maintenance维修率maintainability利用率avaiability可靠性reliability持续性redundancy故障率failure rate故障分类failure mode故障间隔平均时间mean time between failures故障分类及影响分析failure mode and effect analysis故障树分析fault tree analysis安全性fault tree analysis减灾对策fail-safe 防止误差操作fool-proof 安全评价safety assessment 工业事故industrial accident 工业安全industrial safety 安全管理safety management 生产事故labor accident 人身伤害personal injury 事故统计accident statistics 事故费accident cost 伤害原因injury source 人生防护用具personal protective equipment 急救first aid 劳动环境labor environment 16.8 公害环境评估environmental assessment环境标准environmental standard大气污染air pollution水污染water pollution噪音noise土壤污染(1) soil containment(2) soil pollution地基下沉land subsidence。