A1X
150 RF
CS碳钢
-10 到371
?
1
管 道 施 工 手 册 Piping Construction Manuel
4、工艺管道等级汇总表
CLASS等级
A1X
RATING额定 150 RF 值
PIPEMAT'L管 CS碳钢 道材质
TEMP RANGE NDE CLASS ? -10 到371 (C) 探伤等级 温度范围 (C)
A21B19 A21C A21D A21K
-29 到204 -29 到 204 -29 到 204 -101到 204
Ⅳ Ⅳ Ⅳ Ⅳ
A21K19
-101 到 204
Ⅳ
A21L
-196到204
Ⅳ
DRY FLARE干火炬, LIQUID DRAIN液体倒淋, HYDROCARBON低温烃 DRY FLARE干火炬, LIQUID DRAIN液体倒淋, L.T. HYDROCARBON低温烃
304 SS 0Cr19Ni9 S/Stl 304 SS 0Cr19Ni9 S/Stl 304 SS 304 SS 304 SS 0Cr19Ni9 S/Stl 304 SS 0Cr19Ni9 S/Stl
-29 到 204 -2ERALIZED WATER 软水 BIOCIDE SOLUTION除菌溶液DISPERSANT扩散剂, CORROSION INHIBI到R防腐剂PHOSPHATE磷酸盐, NSI BIOCIDE SOLUTION除菌溶液 CORROSION INHIBI到R防腐剂 DISPERSANT扩散剂,PHOSPHATE HYDRAZINE肼 LUBE AND SEAL OIL润滑及密封油 (HIGH AND LOW PRESSURE)高压和低压 DRY FLARE干火炬, L.T. HYDROCARBON低温烃 DRY FLARE干火炬, L.T. HYDROCARBON低温烃 LIQUID DRAIN液体倒淋, LIQUID DRAIN液体倒淋,
Ⅲ Ⅲ Ⅲ Ⅲ Ⅲ Ⅲ Ⅲ Ⅲ Ⅲ Ⅲ Ⅲ Ⅲ Ⅲ Ⅲ
A1P A1PA A1WR
TRANSFER LINES传送管线HYDROCARBON 烃 DECOKING LINES,脱焦VACUUM SERVICES负压介质 STABILIZER COLUMN OVHD (H2S ENVIRONMENT) 稳定器塔塔顶 (H2S环境) PROCESS LIQUID & VAPOUR (LETHAL W/HCN), 工艺液体及蒸汽(致命性物料及HCN), OFFTEST ACRYLONITRILE未检验丙烯腈 PARTIAL VAC CLOSED DRN部分负压倒淋关闭, LIQUID & VAPOUR (LETHAL -5.7PAIS)
SERVICE 介质
液体及蒸汽 (致命物料 -5.7PAIS) PROCESS VAPOUR– LETHAL (FULL VAC, ACRYLO & WTR)工艺蒸汽–致命性物料(全负压) CATALYST (FULL VAC AT CATALYST HOPPERS) 催化剂 (催化剂料斗全负压) A2A 150 RF LTCS -46到 260 Ⅳ COLD FLARE冷火炬, ETHYLENE REFRIG.制冷乙烯, L.T. HYDROCARBON低温烃, LIQUID DRAIN液体倒淋,PPL REFRIGERANT制冷剂 CHLORINATED WATER含氯水 CHLORINE DIOXIDE二氧化氯 DILUTE H2SO4 – PARTIAL FLOW W / AIR, 稀释液H2SO4 –部分液流及 / 空气 A6A 150 RF LINED CS衬 碳钢 FERRIC CHLORIDE氯化铁, SODIUM CHLORIDE氯化钠 -17 到 93 B SODIUM CHLORIDE氯化钠, SODIUM BISULFITE二硫化钠, SODIUM HYPOCHLORITE ACID DRAINS (98% H2S04) SULFURIC ACID (A/GRD only) 次氯酸钠倒淋(98% H2S04) 硫酸(仅A/GRD) HYDROCHLORIC ACID (31%)盐酸 CHLORINATED WATER 氯水CHLORINE DIOXIDE 氯酸 DILUTE H2SO4 – PARTIAL FLOW W / AIR稀硫酸 FERRIC CHLORIDE SODIUM CHLORIDE SODIUM BISULFITE SODIUM HYPOCHLORITE ACID DRAINS (98% H2S04) SULFURIC ACID (A/GRD only) 浓硫酸 DEMINERALIZED WATER (NON-DEAERATED BFW) PHOSPHATE磷酸盐, NSI
A1Y
150 RF
CS碳钢
-10 到 371
?
A6A20
PN2. 0 RF (150RF)
LINED CS (PVDF)
-20 到 93
B
A21A A21A19 A21B
150 RFLJ PN2. 0 RF 150 150 RFWN PN2. 0 RFLJ (150#) 150 RFLJ 150 RFLJ 150 RFWN PN2. 0 RFWN (150RF) 150 RFWN PN2. 0 RFWN (150RF)
0 到 300
0 到 300
?
?
A24A
150 RFLJ
316(L) SS
-29 到 160
B
A24B17
PN2.0 RFLJ 00Cr17Ni14Mo 2 S/Stl (150#)
-29 到200
?
CRUDE & WEAK MAC原M酸及弱M酸 ACRYLIC/ACETIC ACID丙烯酸/醋酸 GLYCOL ACID 乙二醇酸 PROCESS FLARE (LETHAL HCN)工艺火炬(致命性 HCN) PROCESS LIQUID / VAPOUR (LETHAL & CORROSIVE HCN)工艺流体/ 蒸汽(致命性及腐蚀性HCN) GLYCOL ACID 乙二醇酸
CS碳钢 CS碳钢 CS碳钢 CS碳钢 CS碳钢 CS碳钢 CS碳钢 CS碳钢 CS碳钢 CS碳钢 CS碳钢 CS碳钢 CS碳钢 CS碳钢
-10到 427 -20 到 370 -10 到316 -10 到200 -10到 51.5 -20 到 200 -10 到 316 -10 到260 -10 到 260 -10到110 -20 到 110 -10到 427 -10到427 -10 到260
管 道 施 工 手 册 Piping Construction Manuel
4、工艺管道等级汇总表
CLASS等级 RATING额定 值 PIPEMAT'L管 道材质 TEMP RANGE NDE CLASS (C) 探伤等级 温度范围 (C) SERVICE 介质
ATMOSPHERIC VENT大气放空,PLANT AIR工业风, CALCIUM HYDROXIDE氢氧化钙 氢氧化钙(LIME石灰), DECOKING AIR脱焦气, DILUTION STEAM稀释蒸汽, SAFETY VENT 安全放空 LBW (DEAERATED), LBW (已脱氧)OILY-DRAIN含油液 LP STEAM低压蒸汽, LP CONDENSATE低压冷凝液 A1A 150 RF CS碳钢 -10 到 371 Ⅱ FUEL GAS燃料气, FUEL OIL燃料油,NITROGEN氮气, COOLING WATER SUPPLY冷却水供给, RETURN回流, INTERMEDIATE 过渡物流(AG)(UG), CONTAMINATED WATER污水(AG)(UG),惰性气体, NON-CONTAMINATED WATER非污染水, WASTE WATER废水, FIREWATER 消防水(AG), OILY WATER SEWER 含油污水(UG) CHILLED WATER, DECANTED WATER, PROCESS WATER ATMOSPHERIC VENT放空 OILY WATER SEWER污油水 LP STEAM低压蒸汽 FUEL GAS燃料气 LP DENSATE 低压冷凝物 COOLING WATER 冷却水 COOLING WATER冷却水 UTILITY WATER公用工程用水 EB, ORGANICS有机物, HYDROCARBON烃, QUENCH OIL急冷油, STYRENE FEED苯乙烯进料, DEVOL脱挥发份, RUBBER SLURRY橡胶渣泥OLIGMERS低聚物, HYDROCARBON 碳氢化合物 QUENCH OIL急冷油 HYDROGEN氢气 HYDROGEN氢气 93 到 98% SULFURIC ACID93到 98%硫酸 93 到 98% SULFURIC ACID93到 98%硫酸 BT EXTRACTION w /VACUUM抽提及/真空 WET / HOT FLARE干湿火炬 WET / HOT FLARE干湿火炬 SPENT CAUSTIC废碱 HYDROCARBON (WITH CAUSTIC & >5% BENZENE苯 SPENT CAUSTIC (50% Caustic)废碱
A1A20
150RF
CS碳钢
-20 到 370
Ⅱ
A1AA
150 RF
CS碳钢
0 到 66
Ⅱ
A1D A1D20 A1E A1E20 A1F A1F20 A1J A1K A1K20 A1NR
A1NR20
150 RF 150RF 150 RF PN2. 0 RF (150RF) 150 RF PN2. 0 RF (150RF) 150 RF 150 RF PN2. 0 RF (150RF) 150 RF PN2. 0 RF (150RF) 150 RF 150 RF 150 RF